ALERT: Miracle Paint is back in stock! CLICK HERE to order.
Good used working sunroof motor removed from W126 300SD with red clutch adjustment lock nut. There is a very small crack in the red cap, but it should not be a problem if you are careful with it. This motor will also work on 1981 to 1985 W123 but the mounting bracket may be different.
A 12 volt test light is a very handy tool to have when working on any car but it is particularly important if you have a old diesel. This tool will allow you to quickly determine if there is power getting to your glow plugs, and if not where the power is breaking down.
When replacing the steering lock assembly in your Benz you will need to remove that little black plastic switch on the side of the lock from the old one and put it on the new part. You can not pry it off, squeeze it off or pull it off by hand.
Tired of lugging around heavy batteries or battery boosters to test electrical components in your car? It does not have to be a Mercedes. It does not even have to be a car. Anything that runs off 12 volt DC power can be tested by these small, light weight but very powerful batteries.
Electric power seats are great if they are working ok. When they do not work - especially in the fore and aft or tilt movement it can be very frustrating to even drive the car.
If your rear door power window is not moving or the motor is not making any noise, it could be a failed motor, rear door switch, front switch or even a wiring problem. Trying to narrow down the problem can be frustrating unless you know the proper troubleshooting sequence.
If your engine temperature gauge is not reading at all, you need to fix it before you keep driving the car. To ignore this could lead to major engine failure, since you will have no way to get an adequate warning that your engine is about to overheat.
Buy a spare to carry in your trunk! FITS THE FOLLOWING: Late 107 and 116, 123, 126 up through 1991 and 201 and 124 chassis to through 1989. ALSO FITS 1990-1993 300D 2.5 AND 92-93 190E 2.6 ONLY!
Special price only 6 available. New Aftermarket Glow Plug Relay for models and years listing. PLEASE NOTE: cover is not included. You will have to use that from your old relay. Easy install. No instructions included.
Looking for better-staring performance? Are your glow system lights not coming on on your dash even after replacing the glow plugs? It it taking way too long for the glow light to go out ( it should only be on 5 to 10 seconds)?
Yes, there may be a fuse inside or outside your fuse box that controls your heater blower motor or another high amp draw electrical component. Most of the separate fuse holders require a 30 amp fuse. You may find a funny looking bent fuse inside your fuse box.
Fits chassis 116 123 126 124 and 201 Diesels with pencil glow plugs, from 1978 to 1989. This includes the OM617, OM601, OM602, and OM603 engines. They also work on 1977 to 1979 300D 300CD and 300TD with series glow plugs. This pack includes three individual fuses.
Can be installed on the following models: Please read carefully. All Turbo 116 and 126 300SD 1978 to 1985. All 123 turbo and non turbo 240D 300D 300CD 300TD 1980 to 1985. 1984 to 1989 201 190D. 1986 to 1991 126 300SDL 350SD and 350SDL. 1986 to 1993 124 300D and 300TD.
To many people, automotive electrical systems and testing are a big mystery. It is not as complicated as you might think.
When an old Mercedes ( or any other car for that matter ) has sat idle for over a year it can be a challenge to get it safely back on the road again. If it has sat idle for more than 5 years you may find it difficult to even get the engine running.
Malfunctioning and failed power window regulators (mechanisms) are so common on older Mercedes that Kent can almost guarantee if you own one and drive it regularly you will have to fix one at some point.
Motor recently bench tested by Kent. The unit runs smoothly and gears are in good condition.
If you need internal parts for your failed Hirschmann antenna this is the best we have. Very clean and very strong running motor. Recently tested by Kent. Motor runs smoothly and gears are in good condition. Extra parts included as shown.
This is part 8 of Kent's 8-part video series on servicing and repairing the power sunroofs on the 1980 to 1985 W123, W126, and W201.
This is part 7 of Kent's 8-part video series on servicing and repairing the power sunroofs on the 1980 to 1985 W123, W126, and W201. This video will cover ONLY those issues related to the sunroof round motor drive assembly.
Did the engine just quit? Does it just not start even with prolonged cranking? What could it be? The first thing you want to determine with most older cars is whether there is spark to the plugs.
For 1990 to 1995 W124, W126, R129 and W140. Does NOT fit W201 190E.
When removing valve covers or changing wires, replace these with new ones. They may look good, but they usually break due to engine heat and age.
These will no longer be printed when these are gone. They will still be available as a download. All books are signed by Kent. This is an end of an era for us. Most books are approximately 15 pages in length and covered with heavy clear plastic.
Often rotten and torn. Replace with new when working on your fuel delivery system. PLEASE NOTE: These are included when you purchase any of our fuel pump delivery kits.
In this 10 minute instructional video Kent will explain why you want to "jump" your K-jet fuel pump relay, how to do it, how to find the location in you car, and why he prefers to have a long "switchable" jumper.
This is a high-quality ACM aftermarket part. The fan runs smooth and air movement is very strong.
Is your old gas engine running a little rough? There could be lots of reasons for this but if you have good compression, good plugs and wires you might consider replacing your O2 sensor even if your warning light is not showing up. This is an easy DIY job.
This is a part that hardly ever gets changed, and it is an easy DIY job if you can access it under your Benz. Make sure your model fits those described and has an O2 sensor installed. You can confirm that by the existence of an o2 sensor warning light on your dash.
To many people, automotive electrical systems and testing are a big mystery. It is not as complicated as you might think.
This 17-minute video will cover the removal of an old Hirschmann power antenna and then Kent will show you how to troubleshoot the wiring plug in the car to see if you are getting proper power back to the antenna. No sense in replacing a faulty antenna until you make sure your wiring is OK!
In this xx-minute long video, Kent will show you how to install our aftermarket power antenna in your 116, 123, or 123 sedan or coupe. Removal of your old antenna is not covered in this on-demand video but it is very straightforward once you remove the inner fender well panel.
Power Hirschmann antennas are no longer available new. It is possible to remove and repair the old Hirschmanns if you are willing to dig in and spend time cleaning, adjusting, lubing, etc.
When the motor won't move the window down you can not get to the bolts that hold the regulator to the glass. So then how can you get it out of the door! What a pain! In this xxx minute video Kent will show you what you need to do in order to get a "stuck" power window regulator out of a door.
Fuses, supplies, and video instructions (below) to restore most older fuse boxes to better than original condition.
Fuses, supplies, tools and video instructions (below) to restore most older fuse boxes to better than original condition.
This is a must-have if you have a prized Benz or any car you don't drive often!! If you let any of your cars sit for long periods ( generally over 30 days) without driving them, you can ruin your battery, especially if you let it go completely dead.
Good used plug and wire as shown for the AC compressor. Will need to be spiced into your original wiring.
Free PDF written instructions included. Only fits 126 Chassis gasoline 6 and 8 cylinder 1981 to 1989 - See model list below
In this video instruction Kent will show you how he installs our battery tender kit in a W124 Mercedes.
After years of "fighting" fuse replacement, Kent finally decided he had had enough! And so was born another special tool. It is designed to securely grab hold of a ceramic fuse, remove it from it, and replace it with minimal exertion and no damage.
Jammed up steering locks and keys that won't turn can leave you stranded.
Kent explains why it is important to to remove and open up the motor assembly anytime you are replacing a damaged cable. On the bench he explains the workings of the motor and transmission and shows close up examples of what each of the different components do.
Tilting power sunroof problems can be many. This is particularly true on roof mechanisms that have not received proper lubrication over the years. One of the first things that can fail is the power sunroof cable.
In this video Kent explains some of the key reasons for poor battery contact and loss of voltage to important electrical components. If you want your later model Mercedes to run a peak performance pay attention to your battery.
IMPORTANT NOTE: We do not sell replacement antenna masts by year and model. We have run across too many problems with confusion, interchangeability, and previously swapped antennas. We sell a SMOOTH TAIL mast and a TOOTH TAIL mast.
Have you been having electrical problems in your older Mercedes? Maybe you have taken the fuse box cover off and wiggled a few fuses and it has solved the problem for a while. You probably noticed corrosion on the tips of the old aluminum fuses.
Digital PDF instructions for cleaning your pencil glow plug chambers. 5 pages of step by step instructions with detailed pictures to visually assist you in completing the job.